MV Cougar Ace

Loss of stability incident

On 23 July 2006, she was en route from Japan to Vancouver, British Columbia; Tacoma, Washington; and Port Hueneme, California, with a cargo of 4,812 vehicles. During an exchange of ballast water south of the Aleutian Islands, she lost stability and developed a 60° list to port. There were reports of a large wave striking the vessel during the ballast transfer, but it is unknown what effect this had on her loss of stability.{{cite web On 24 July, the United States Coast Guard and the 176th Wing of the Alaska Air National Guard successfully rescued the 23 crew members.{{cite web

4,703 (97.7%) of the vehicles on board were from Mazda; 60% were 2007 Mazda3s and 30% were Mazda CX-7s. The remaining Mazdas were mainly RX-8 and MX-5 models. According to Car and Driver magazine, the exact contents of Mazda's shipment were 2,804 Mazda3, 1,329 CX-7, 295 MX-5, 214 RX-8, 56 Mazda5, and 5 Mazdaspeed6 models. The remaining 2.3% of the vehicles on board (approximately 110 vehicles) were from Isuzu, mostly Isuzu Elf trucks. In total, the cargo had an estimated value of US$117 million.

Salvage effort

A marine salvage team from Titan Salvage arrived on site on 30 July 2006. Led by Salvage Master Captain Rich Habib, the team was able to get aboard the vessel via a U.S. Coast Guard helicopter from the cutter . Later that day naval architect Marty Johnson slipped and fell to his death as the salvage team was preparing to leave the Cougar Ace and board the tugboat Emma Foss.{{cite web|url = http://www.seattlepi.com/local/279563_listingship01.html.

Titan Salvage subsequently towed the vessel through Samalga Pass to the north side of the Aleutian Islands for protection from the weather using the tugboats Sea Victory, Gladiator and Emma Foss. It was then taken to Unalaska Island, where it was moored to Icicle Seafoods' mooring buoy. Cougar Ace was righted and redelivered to Mitsui Group on 16 August 2006, and on 25 August put under tow to Portland, Oregon for inspection and repair.

Disposition of cargo

Mazda officials reported minimal damage to the vehicles on board despite the ship listing for over a month. However, according to the US Coast Guard, 41 vehicles broke loose and shifted.

On 11 September 2006, one day before the Cougar Ace arrived in Portland to begin unloading, Mazda USA announced that none of the Mazdas aboard would be sold as new vehicles. Mazda USA published a list of VINs for the affected Mazda vehicles on their website.

On 15 December 2006, Mazda announced that all vehicles on the Cougar Ace would be scrapped. After an extensive process to deploy all the airbags in each vehicle, all of the Mazda cars were crushed onsite at the Port of Portland by Pacific Car Crushing. The last Mazda car from the shipment was crushed on 6 May 2008.

Appearances in media

The Cougar Ace was covered extensively by the automotive press because of the sheer number of new cars that Mazda scrapped after the incident. She has a cameo of sorts in episode one, season three, of the television series Deadliest Catch. She is shown, temporarily anchored in Dutch Harbor in the Aleutian islands, awaiting further recovery.

Scrapping

In June 2020 MV Cougar Ace was sold for scrap. She was beached at Alang, India on 23 June 2020 and cut up thereafter.

Gallery

File:CougarAceListing24july2006.ogg|Video File:Cougar Ace from bow.jpg|The Cougar Ace listing on 14 August 2006 (over three weeks after the incident), view from the bow File:CougarAceListing24july2006-1.jpg|View from above File:Cougar Ace Listing Aft view and screw.jpg|The rudder and the propeller of MV Cougar Ace are lifted after her 60° list to her portside.

References

References

1. "Cougar Ace".
2. (27 June 2006). "Mazda Vehicles Aboard Stricken Car-Carrying Vessel, Cougar Ace". [[Mazda Motor Corporation]].
3. (1 October 2008). "Cougar Ace: The Great $103 Million Snafu at Sea". [[Car and Driver]].
4. "Cougar Ace salvage operation turns deadly". autoblog.com.
5. Demer, Lisa. (27 August 2006). "Finally Upright, Cougar Ace will be Portland Bound". Anchorage Daily News.
6. "NO MAZDA VEHICLES ON CAR-CARRYING VESSEL COUGAR ACE WILL BE SOLD AS NEW".
7. "ALL MAZDA VEHICLES FROM CAR-CARRYING VESSEL COUGAR ACE TO BE SCRAPPED".
8. "scheepvaartwest - Cougar Ace - IMO 9051376".
9. Des Bois, Robin. (30 June 2020). "Cougar Ace. IMO 9051375.". Shipbreaking: Bulletin of Information and Analysis.